Product ID:4374 EXTRA-LITE BODY FILLER
MSDS Date:09/10/1986
FSC:8010
NIIN:00F049549
MSDS Number: BZWDJ

Emergency Phone: 216-566-2917/216-566-2902

Info Phone: 216-566-2902/216-566-2917

Cage: 54636

Telephone: 800-251-2486/216-566-2242

Cage: 54636

STYRENE, STYRENE MONOMER (SUSPECTED ANIMAL/HUMAN

CAS: 100-42-5

RTECS: WL3675000

Fraction By Weight: 15-20%

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE CAUSES EYE, SKIN &
RESPIRATORY IRRITATION. MAY CAUSE NERVOUS SYSTEM DEPRESSION.
EXTREME OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS & DEATH.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEMDEPRESSION.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
CONFUSION, STAGGERING GAIT.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE
AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:PMCC
Flash Point:100F
Lower Limits:1.1
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT & IGNITION SOURCES. CLOSED CONTAINERS MAY EXPLODE DUE TO
EXTREME HEAT.

Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.

Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. PROTECT
AGAINST DUST WHICH MAY BE GENERATED BY SANDING/ABRADING THE DRIED
FILM.
Other Precautions:DON'T PUT ANY MIXED MATERIAL BACK INTO THE CAN OF
UNMIXED FILLER. AVOID BREATHING VAPORS & SPRAY MIST. AVOID CONTACT
W/SKIN & EYES.

Respiratory Protection:IF EXPOSURE CAN'T BE CONTROLLED BELOW APPICABLE
LIMITS, USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION
Protective Gloves:REQUIRED
Eye Protection:SAFETY GLASSES W/UNPERFORATED SIDESHIELD
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:293-294F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:EXTRA-LITE BODY FILLER
Percent Volatiles by Volume:25

Stability Indicator/Materials to Avoid:YES
PEROXIDES, STRONG ACIDS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2, CO

Waste Disposal Methods:MAY BE HAZARDOUS, MUST BE TESTED FOR
IGNITABILITY. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE
CLOSED CONTAINER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.